Access TonnoSport Soft Roll-Up Tonneau Cover for 1994-2002 Dodge 1500 / 2500 / 3500 / Ram 1500 / 2500 / 3500 (6'6" Bed)

Height is the headline on the Access TonnoSport. Closed, it stands half an inch over the bed rails, roughly a third of what a typical roll-up adds. The satin black grain tarp reads as part of the truck rather than something bolted to it. Silver anodized aluminum makes up the frame and a tension controller holds the vinyl taut whether it is freezing or baking outside. Trigger latching happens by itself on closing, with slide locks that pin the cover to the rails. Access pitches it as the budget entry to its roll-up range. Part number 22040119 is the 6'6" bed application for the 1994-2002 Dodge 1500 / 2500 / 3500 / Ram 1500 / 2500 / 3500.

What's Included:

• Grain finish vinyl tarp in satin black
• Silver anodized aluminum side rails
• Tight Bite clamps and fasteners
• Integrated tension controller
• Nylon straps for the rolled cover
• Instructions for your bed type

Features

Half An Inch Of Profile
Most soft roll-ups stand about an inch and a half above the bed rails. This one clears them by half an inch, so from the side the cover is barely there and the bed line of the truck stays clean.

Silver Anodized Aluminum Frame
The frame under the tarp is anodized aluminum in silver, chosen because it is light and does not rust in the bed. It supports the vinyl across the width without adding real weight to the tailgate end.

Trigger Latch And Slide Locks
Lower the cover and the trigger latch engages by itself. Slide locks on the opposite side then pin the cover to the bed rails, and with the tailgate shut behind them there is no simple way into the bed.

Front Element Seal
A seal at the bulkhead end blocks the gap where water and road dirt normally work their way in from the cab side. Rain that hits the grain finish tarp beads and runs off toward the rails.

Stake Pockets Stay Open
The rails are shaped to leave your stake pocket holes accessible, so bed accessories that use those holes keep working. That is rare on a cover this low and useful if you tie down loads regularly.

Tension Controller Built In
One adjuster governs how tight the vinyl sits across the frame. Take up the slack after a cold snap or a long spell in the heat and the tarp goes back to a flat surface instead of holding a dip.

Fitment & Compatibility

Specifications

• Cover Type: Soft roll-up
• Material: Marine grade vinyl over anodized aluminum
• Finish: Satin black, grain texture
• Profile Height: Half an inch above the bed rails
• Bed Access: Rolls to the bulkhead, straps hold the roll
• Sealing: Front element seal at the bulkhead
• Security: Trigger latch plus slide locks to the rails
• Frame: Silver anodized aluminum
• Tension Adjustment: Integrated tension controller
• Stake Pockets: Remain accessible
• Drilling Required: No, Tight Bite clamps
• Fits: 6'6" bed, see fitment table
• Weight: About 27 lb
• Made In: USA
• Warranty: 2 year limited

Installation

Type: Clamp-on, no drilling · Time: Varies by truck and bed, see the installation guide · Tools: Supplied clamps and hardware, a socket set · Difficulty: Easy, one person

No part of this fitting needs cutting, trimming or a drill. The tight bite clamps pull the rails against the inside of the bed and hold them there. Unroll the tarp over the frame, close the hook and loop along each side, then use the tension controller to take out the slack. Drop the cover once to check the trigger latch catches.

Warranty, Shipping & Returns

Warranty. Access gives the TonnoSport a 2 year limited warranty on defects in material and manufacture, the shortest term in its roll-up range. A defective part is repaired or swapped at the maker's discretion and the cover does not pay for labor or fitting time. Incidental, consequential and special damages are outside the terms, as are implied warranties of merchantability. State law may grant you more.

Free shipping. This item ships free to the lower 48 states. Because it is an oversized item, it ships by freight or oversized parcel and typically arrives in 3 to 7 business days.

Inspect on delivery. Please inspect the packaging before signing. If you see any damage, note it on the delivery receipt and contact us right away, and we will make it right.

Returns. Unused items in their original packaging can be returned within 30 days of delivery. If an item arrives damaged, defective or wrong, return shipping is on us. See our Returns & Refunds Policy, or email support@prestigetruck.com with any question.

About Access

Access makes truck bed covers in the United States and spreads its roll-up line across several price points. The TonnoSport is the entry model, so it trades the perimeter gasket set and the longer term of the upper covers for a lower price and the lowest profile in the family.

Common parts run through the whole range. Whichever cover you buy, the frame is aluminum, the tarp is vinyl, mounting is done with clamps on the bed lip and the latch closes as the cover comes down, which keeps fitting and spares familiar across models.

The line is engineered per vehicle. A TonnoSport exists for crew cabs, double cabs, stepside and flareside boxes, CarbonPro beds and trucks with a multifunction tailgate, each as its own part rather than one cover trimmed to fit.